Product ID:TURCO TRANSPO GX (NEW FORM)
MSDS Date:01/15/1986
FSC:6850
NIIN:00-543-7801
MSDS Number: BFDQX

TURCO PRODUCTS, INC.

7300 BOLSA AVE
WESTMINISTER, CA 92684-3600
US

Emergency Phone: 614-387-6200

Info Phone: 714-890-3600

Cage: 0BYN5

TURCO PUREX INDUSTRIES SUB OF PENNWALT CORP

WESTMINISTER, CA 92683-5211 US

Telephone: 614-387-6200

Cage: 1JD46

PHENOL

CAS: 108-95-2

RTECS: SJ3325000

OSHA PEL S, 5 PPM

ACGIH TLV: S, 5 PPM; 8990

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

METHYLENE CHLORIDE (SARA III)

CAS: 75-09-2

RTECS: PA8050000

OSHA PEL 500 PPM/C,1000; Z2

ACGIH TLV: 50 PPM, A2; 9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

SODIUM BICHROMATE (SARA III)

CAS: 10588-01-9

RTECS: HX7700000

OSHA PEL 0.1 PPM CRO3;CEILING

ACGIH TLV: 0.05 MG CR/M3; 9192

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

OCTYL PHENOL POLYETHYLENE GLYCOL ETHER

CAS: 9002-93-1

RTECS: MD0907700

Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:CORROSIVE! CONTAINS DICHROMATE
CARCINOGEN. CORROSIVE DAMAGE POSSIBLE ON ALL EXPOSE TISSUES;
ORGANIC VAPORS MAY CAUSE HEDACHES & DIZZINESS. CHROMATES ATE SKIN
SENSITIZERS. METHYLENE CHLORIDE IS SUSPECT ED HUMAN CARCINOGEN.
Explanation of Carcinogenicity:HEXAVALENT CHROMIUM IS A CONFIRMED HUMAN
CARCINOGEN. METHYLENE CHLORIDE IS A SUSPECTED HUMAN CARCINOGEN.
Effects of Overexposure:EYE:SEVERE IRRITATION POSSIBLE, EXPOSURE TO
LIQUID MAY CAUSE BLINDNESS. SKIN:BURNS, NECROSIS, DEFATTING,
ABSORPTION, SENSITIZATION. INHALE: DIZZINESS, HEADACHE, INTOX,
CORROSIVE DAMAGE TO RESP TRACT. INGESTION: SEVERE GI TRACT
IRRITATION, DELAYED TOXIC EFFECTS, POSSIBLY FATAL.
Medical Cond Aggravated by Exposure:IMPAIRED CARDIO.PULMONARY FUNCTION
MAY BE FURTHER AGGRAVATED BY METHYLE CHLORIDE METABOLISM.

First Aid:EYE:FLUSH 15 MINUTES W/AMPLE WATER. SKIN:WATER FLUSH THEN
WASH SOAP & WATER AND RINSE. INHALE: REMOVE TO FRESH AIR, GIVE
OXGEN OR ARTIFICIALS RESP AS REQUIRED. INGESTION: DO NOT INDUCE
VOMITING. IF CO NSCIOUS, GIVE LARGE QUANTITY WATER OR MILK. GET
PROMPT MEDICAL ATTENTION IN ALL CASES. TRY TO DETERMINE EXPOSURE
DOSAGE.

Flash Point:NONE
Extinguishing Media:CARBON DIOXIDE, FOAM, WATER FOG.
Fire Fighting Procedures:USE SCBA PP MODE WHEN FIGHTING FIRES. RUNOFF
WATER MAY CONTAIN HEXAVALENT CHROME AND MUST NOT ENTER SEWER OR
WATERWAYS.
Unusual Fire/Explosion Hazard:DRUM RUPTURE POSSIBLE ABOVE 100F.

Spill Release Procedures:CONTAIN SPILL, STOP LEAK, VENTILATE AREA,
EVACUATE NONESSENTIAL PERSONNEL. SHOVEL OR PUMP SPILLAGE INTO
CLOSABLE DRUMS. COLLECT REMAINDER W/ABSORBENT, PLACE IN DRUMS.
WASHDOWN SPILL AREA, COLLECT WAS HWATER AND DON'T ALLOW ENTRY INTO
SEWEROR STREAMS
Neutralizing Agent:NONE GIVEN

Handling and Storage Precautions:STORE IN COOL, SHADED, DRY AREA.
VAPORS ARE HEAVIER THAN AIR, MAY COLLECT IN LOW AREAS-ASPHYXIATION
HAZARD.
Other Precautions:FOLLOW ALL NOTMAL SAFETY PROCEDURES WHEN ENTERING
CONFINED AREAS: USE RESPIRATORY PROTECTION,SAFETY LINE, WORK IN
PAIRS.

Respiratory Protection:USE SCBA PP MODE W/FULL FACEPIECE.
Ventilation:GENERAL MECHANICAL
Protective Gloves:IMPERVIOUS, NEOPRENE
Eye Protection:GOGGLES, FACEPIECE.
Other Protective Equipment:APRON, BOOTS OF NEOPRENE.
Work Hygienic Practices:WASH SOAP & WATER BEFORE EATING OR SMOKING.
REMOVE ALL CONTAMINATED CLOTHING, CAUNDER BEFORE REUSE AT JOBSITE
ONLY.
Supplemental Safety and Health

HCC:C2
Boiling Pt:=40.6C, 105.F
Vapor Pres:500
Vapor Density:>1
Spec Gravity:1.09
pH:8-10
Evaporation Rate & Reference:(BUAC = 1), <1.
Solubility in Water:APPRECIABLE
Appearance and Odor:TWO LAYER LIQUID, PHENOLIC ODOR.
Percent Volatiles by Volume:75%

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDIZERS.
Stability Condition to Avoid:EXCESS HEAT, OPEN FLAMES
Hazardous Decomposition Products:CARBON OXIDES, PHOSGENE,ACID
GASES,OTHER VOLATILE TOXIC ORGANICS.

Waste Disposal Methods:RECLAIM AND RECYCLE FOR SOLVENT RECOVERY OR
CHEMICALLY TREAT BY LICENSED CONTRACTOR. ORGANICS DISPOSAL BY
INCINERATION AND/OR CARBON TREATMENT.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.